CP5.241, CP5.241-C1,

CP5.241-S1, CP5.241-S2

CP-Series

Aug. 2017 / Rev. 0.1 DS-CP5.241-EN

All parameters are typical values specified at 24V, 5A output, 230Vac input, 25°C ambient and

after a 5 minutes run-in time unless otherwise noted.

www.pulspower.com Phone +49 89 9278 0

Germany

P R E L I M I N A R Y

Switching Frequencies

PFC converter

70kHz to 130kHz

Input voltage and output power dependent

Main converter

60kHz to 140kHz

Output load dependent

Auxiliary converter

60kHz

Fixed frequency

-25°C to +70°C (-13°F to 158°F)

Reduce output power according to Fig. 15-1

Storage temperature

-40°C to +85°C (-40°F to 185°F)

For storage and transportation

Output de-rating

1.6W/°C

3W/°C

Between +45°C and +60°C (113°F to 140°F)

Between +60°C and +70°C (140°F to 158°F)

Humidity

5 to 95% r.h.

According to IEC 60068-2-30

Do not energize while condensation is present.

2-17.8Hz: ±1.6mm; 17.8-500Hz: 2g

2 hours / axis

According to IEC 60068-2-6

30g 6ms, 20g 11ms

3 bumps / direction, 18 bumps in total

According to IEC 60068-2-27

Altitude

0 to 2000m (0 to 6 560ft)

Without any restrictions

2000 to 6000m (6 560 to 20 000ft)

Reduce output power or ambient temperature

according to Fig. 15-2

Altitude de-rating

7.5W/1000m or 5°C/1000m

Above 2000m (6500ft), see Fig. 15-2

Over-voltage category

III

According to IEC 62477-1 for altitudes up to

2000m

II

For altitudes from 2000m to 6000m

Degree of pollution

2

According to IEC 62477-1, not conductive

LABS compatibility

The unit does not release any silicone or other LABS-critical substances and is suitable for

use in paint shops.

Audible noise

Some small audible noise will be emitted from the power supply

Corrosive gases

ISA-71.04-1985, Severity Level G3, IEC 60068-2-60 Test Ke Method 4

Audible noise

Some small audible noise will be emitted from the power supply

1) Operational temperature is the same as the ambient or surrounding temperature and is defined as the air temperature 2cm below the unit.

2) Tested in combination with DIN-Rails according to EN 60715 with a height of 15mm and a thickness of 1.3mm and standard orientation.

Fig. 16-1 Output current vs. ambient temp.

Fig. 16-2 Output current vs. altitude

Allowed Output Current at 24V

15/26

0

-25

0

20

40

70°C

1A

2A

3A

4A

5A

6A

60

A

A... 85 to 264Vac, continuous

B... short term

B

0

0

2000m

4000m

6000m

1A

2A

3A

4A

5A

6A

Allowed Output Current at 24V

Ambient Temperature

Altitude

B

C

A... Tamb < 60°C

B... Tamb < 50°C

C... Tamb < 40°C

D... Short term

A

D